软化器参数计算及选型

DR2单罐软化阀 纡萍鼍::T/'轩乏h”tonk softening Single volve浮动床软化控制阀LED显示互垂液晶显示家用冁苓枇蠹可囔 蠹移骺钓耀毽毽撵High hardness water degree of softeningprinciple 1. lt adopts the regeneration quality backflow controlling of floating bed; The of water is highwhereas the consumption of salt is low;2. No hard water runs through ihe equipment for the industrial type. lt is suitable in some situationswhere for the quality the requirements of water are high, such as boilers.3. The sealing for the core of planar valve adopts ceramic non-wear type and guarantees reliableusage.(or English) operating interface 4. The Chinese shows the instant and accumulated amount of water.pattern 5. There are two modes to choose from: full-flow and time mode. lt has the memory functionwater.of cutting off the electricity and 6. lt is easy to be installed and adjusted and needs no operation from the user.pattern.7. it can be forced to be sei regeneration time of day in flow 省树陇、0 06-0 4MPa5t/h-3t/h〈12mm°l/L'流量(默认)/时间1000ⅢⅢo1/L出水硬度盐耗〈0 03mmOl/L△作交换容量〈88g/lm。自用水率:〈3%业配置)招爿孛酉己墨i(△〈3t/h丨〈10mmo1/L|<3t/h∶〈12Ⅲmol/u300米1650 | 350米1650 |脂装填量(升)|树交换罐容积的90%仂口水前填满)|扩s卩喋嵘|(sa1t)黟黔\\2.5inch-8U[树脂装填量(升50%]/原1L))米水硬度(mm。控制流程1 再凳2 j焉j走︱3 扌化丨卩卩|_∶吸盐管(sa t pipe)、∶(3/8″)电源插座(Power°uuet)220v上布水器(top |ooat°r)F0601中心管(Center0Dpipe)1 05″(中心管上端口低于罐口10mmThe t°p of p|pemust be |ower10mm)树脂填充率ng rate(The f\"Ⅱof resin)90%下布水器cat°r)(bottom |。|F0602盐阀(Sa tva丨ve)JYYF(水满逆止盐阀Fu丨I stop valve)布水器(上) 布水器(下)绉宀(专用)B㈣∵rlnYfev7F 「ZR4双罐顶装软化阀畏走产水罾:5T肘tonk softening volveDubble 浮动床软化控制阀`〓硬尽'·禹,覆至的另今口滔动床寓硬水,名水、名绉、堵树陇、獗亿流量/日寸间双模式两交换罐同时产水,交替再生,软水清洗进水压力低,停水、停电记忆ˉ平面阀陶瓷密封-ˉwear sea\"ng;cutting offthe inΠMicrocomputer planar valve;nonˉow、vhen shifting location;uence on the qualⅡexerting no in旧y of water;FIOating bed ion swkCh;baCkfIOw regeneration;doubIe pots vvorking a\"ernately;softening water at high degree of hardness∶ressure of;nflow is O05MPa,the equipments can stⅢEven ifthe ρworκ ebso「0selt en¤出水口DN25左出水;右泔洗主交换罐副交换罐(左交换罐)制水量和原水硬度额定运行压差左出水;右出水运行流速再生剂比耗电源及功耗软化残硬盐阀自用水率小于3T/ll; 小于于4T凡; 小121nmoL/L 小于于5T/ll;15mllc,VL/l、〃L 小f811nn【0~08bIPa O15bΙPa 020bIPa⒈14或眇g/luol交流电源220V;功耗003kav不大于0.O31111no1/LⅥ\"00(注水截流、注水保护、空气逆止)小于5%(与原水硬度有关〉2¨屋氢彳仝250×1350 2-卫蔓彳歪300×1650 2-罡垂彳歪350×1650盐箱容积树脂装填量左再生;右出水工位半周期制水量(吨)100:升 200升交换罐容积的90%-95%30÷原水硬度 90÷原水硬度原水硬度 50÷f-oVL) lmnoyL) f-oL/L)参数 再生时间(分钟)清洗时间(分钟沪101015122015苄清洗时间与出水管背压有关,所设定时间须保证清洗结束前3分钟内排污口无味为准。左泔洗;右出水左出水:过滤器盐阀YF300·浮动床软化控制阀1、浮动床控制原理,双罐交替再生同时产水,系列配置交换罐直径小,树脂装量少;2、平面多路阀零件采用高强度材质注塑成型,阀内采用陶瓷无磨损密封;3、采用盐水流量变送器和软水流量变送器,按原水硬度设定周期制水量和周期盐水量;4、配合液位开关自动控制设备起停,无需操作。5、控制器人性化中文操作界面显示各类运行参数,并具有停电停水记忆功能;High degree of hardness water softenin丬 It adoρing principle;Two tanks recycIe and produce Water aⅡts】oa刂ng bed controⅡernatively;The diameterofthe swap tank is sma\"and the loading amount of resin is sma\";2 The comρonents ofthe planar muⅡiple unit valves use highˉstrength rnaterials in the molding procesceran1ic non-wear seaⅡng rnethod is adoρted inside the vavIe;3 FloW transnηitters of both sa\"y Water and so段ened water are adopted; The periodical amount of lding to the hardness of raw water∶production and that of brine water production is set accoΓ4 The equipment can coordinate with the Ⅱquid level switch and turn itsef on and off automatica\"no operation from the users;aCe in Chinese(EngI⒗5~ControIlerB human⒓ing operaung inte汀h)disρlays different kinds of ρarameters;\"can aIso turn ofFthe electHcity and wate1and conduct ConsumpIion ;鼾硬水筱亿(廛: 10-25T/h墼列∵(乐习泺Ⅱi亻型号额定制水量额定运行压差运行流速再生荆比耗电源及功耗软化残硬原水硬度自用水率)交换罐 (上下4〃(个数×直径×有效高度)盐箱容积树脂装填量布水器(4″钥UN)RF20-1010吨/`J`时RF20-15RF20-2020口电/`J、日寸RF20-2525盹/`J、时15吨/小时Pao~10Ⅲ15巧5米绉向Br丨ne v¤|ve0 08MPao 12MPa/'J、时o 15MPa1∶1~4或82g/moI交流电源220V;功耗003kw不大于00snlmo/L不大于6mm°l/L;H:不大于12nulqo l/L;Ⅲ:不大于⒛mrr o l/L(参考原水报告〉;不大于5%(与原水硬度有关)2-直1636 2直1636 ⒉I 2直径娟0×13681600径sO0×径sO0×直径750×1650I1 2-直2-直1800 2-直1800 2-直1800径450×径GO0×径600×径750×lH 2-直zO002直径600×2200 ⒉2200 ⒉2200直径750×径sO0×直径750×350升500升 500升 800升95%交换罐容积的90咿40片DF40DN40117÷原水硬度4760片 80片 100片DF40 DF50 DF5oDN40 DN50 DN50173÷原水硬度 394÷原水硬度 253÷原水硬度69 101 158电磁阀(先导式)进出水管径周期制水量(吨)设定 周期盐水量(升)清洗时间(分10钟),k过滤器控制流程工位1:到曰出水;圭灯再生(起始工位〉工妲:0l曰出水;圭铂济洗工位3:Dl钴出水;主扌出水布水器工0=:0l扌再生;主0出水圭扌出水工位6:0l0出水;主铂山水电磁阀出水单向阀DR4单罐软化阀畏大加卜罾:6THtonk Single softening volve冼浮动床软化控制阀LED显示液晶显示High degree of hardness water softenlng1. lt adopts the principle backflow regeneration controlling quality of floating bed; The is highof water whereas the consumption of salt is low;2. No hard water runs through the equipment for the industrial type. lt is suitable in some situationswhere the requirements for the quality of water are high, such as boilers.3. The sealing for the core of planar valve adopts ceramic non-wear type and guarantees reliableusage.(or English) operating interface The Chinese shows the instant and accumulated amount of water.pattern There two modes are to choose from: full-flow and time mode. lt has the memorv functionof cutting off the electricity water.and 6. lt is easy to be installed adjusted and needs and no operation from the user.7. it can be forced to be set regeneration time of day in flow pattern.推荐配置〈8ⅢⅢol/L |〈4t/h;<12ⅢⅢol/L<6t/h;<12Ⅲmo1/1按产水量和原水硬度〈在t/h∶交换罐(直径皿Ⅲ米高树脂装填量σ卜)盐桶(爿)再生(升)流量模式参数设定清洗(升)软化(吨)300米1650 | 350米1650400米1850交换罐容积的90%O口水前填满)不小于200升70%)苄树脂装填量(升]50%)米树脂装填量(升50%]/原[树脂装填量(升)米水硬度(mmo1/L)控制流程⒃Jn哞∵1¨矿鹬Ⅰ 、 ¨(:∫∷、∷Ⅱ撼蘧屮:,∵爨爨饔:=^¨2、清洗o|eop ng︱3、欺化卜;OrⅡng0丨丨卩F绉阎Yf300Brine v¤丨ve上布水器ocat°r)(top 丨中心管(Genter心管上端口(中与罐口平齐)pipe)直径32mmOD树脂填充率(The fi\"ing rate0%of resin)θ过滤器下布水器〈bottom l°。ator)) 布)布水器(上水器(下sa tva ve)YF30盐阀〈(水满逆止盐阀Fu l stoρ valve)DR10单缶萑饧歹5扬乡装阀颍磁phoan aa(aelo{ - had,eaV ·石其⒓肜浮动床软化控制阀High hardness degree of water softeningprinciple 1 . lt adopts the backflow regeneration controlling of floating bed; is highThe quality of water whereas the consumption of salt is low;2. No hard water runs through the equipment for the industrial type. lt is suitable in some situationsfor the quality where the requirements of water are high, such as boilers.3. The sealing for the core of planar valve adopts ceramic non-wear type and guarantees reliableusage.4. The Chinese (or English) operating interface shows the instant and accumulated of water.amount pattern 5. There are two modes to choose from: full-flow and time mode. lt has the memory functionoff the electricity and water.of cutting 6. lt is easy to be installed and adjusted and needs no operation from the user.7. it can be forced to be set regeneration time of day in flow pattern. Fg{4进水压力 om~o+llh 出力范围 6t′~⊥2t``h原水硬皮 〈12咖∷。丨l +ˉ制杖式 流量、时问双模式出水硬吱 (oo3mⅡ。l'| l∶作交换容景 1ooomn ol'I盐札 亻出g`\"ol 交损流速 1o~6oll h白则水衤 “%(}J「T水殛度相夫) ,H出) ±l水接「 (ll·推荐配置h)额定产水量(〃运行压差(VIPa)运行流速(m/ll)树脂装填量(升)耠桶(升)″生流速(〃h)清洗流速(m/h)8 ⊥o 12-0 壬0 06rˉ5I0-60交换罐(胄Φ450×径【胆高)nlm167o Φ5oo×1750 Φ600×1850交换罐容积的90%(加水前填满)≥ZCl0升 ≥35o升 ≥4′l⊥6′⊥35oo升流参}聂蒌奎屠 {雾控制流程树脂装填量(升)×70%口\\罐树脂装填量(升)×15叽软化(ⅡL)[树脂装填量(升⒛O。)×l÷原水硬度(llullol`/L)-8UN4″2 |苒”︱卩一一∷∷△J|∷江一〓 `·η盥⑶Brine v¤|ve上布水器F182s°。at°r)(top 丨中心管(Center过滤器pipe)直径50mmOD(中心管上端口与罐口平齐)树脂填充率(The fil\"ng rateof resin)90%下布水器F182X。cat°r)(bottom 丨盐阀YF600过滤专用阀·彳实用新型:ZL20092003169矣过滤专用⒓肜刂全工位水量设定∶量H1汩￡馑萤 仝工位时间设定`、 进出口径咖擗污口径相同`保证焦泷水量'纟、可广泛痖闱于砂滤、联滤、除蛾炀合/罗、年面阃忐陶啜琵房损窑衬'召、安裘简俊,使跽可甫r'| ~'''广\\出,lqDN20出水DN404inch-8UN进水DN40爿卜污DN40/0 5inch-8UNDN20引:污控制流程1. E)ftBack washiHΓ1、浮动床控制原理,双罐交替再生同时产水,系列配置交换罐直径小,树脂装量少;2、平面多路阀零件采用高强度材质注塑成型,阀内采用陶瓷无磨损密封;冼浮动床软化控制阀3、采用盐水流量变送器和软水流量变送器,按原水硬度设定周期制水量和周期盐水量;4、配合液位开关自动控制设备起停,无需操作。5、控制器人性化中文操作界面显示各类运行参数,并具有停电停水记忆功能;寓硬 筱亿产水量:30-50T/h推荐配置¨ 型号额定制水量额定运行压差运行流速再生剂比耗电源及功耗软化残硬原水硬度自用水率-法交换罐 (上下6″兰) I(个数×直径×有效高度) HIⅡ盐箱容积树脂装填量叠片式高效通流布水器电磁阀(先导式膜片)进出水管径工位参数设定 周期制水量(盹)60片(6″法兰)DF65DN652-直径2-直径2直径交流电RF3030t/ho 16mPaRF4040t/ho 18ⅢPaRF5050t/ho 28MPa向Bri∩e绉、15-55米/刂日寸1∶1 4或82g/m°I源220V;功耗o^o3kwv︱v¤e≤≡0 03mmoI/LI : ≤≤6mm°l/L; II:≤12mm°l/L;Ⅲ:≤⒛mm。l/L(参考原水报告);≤5%(与原水硬度有关)750×1513750×18oo750×22oo8002-直径2直径900×1587900×⒛oo900×23oo10002直径2-直径2-直径1000×15871000×2ooo10oo×23oo10002-直径交换罐容积的90%-95%80片(6″法兰)DF80DN8000DF80DN80375÷原水硬度15030576÷原水硬度230407⒛÷原水硬度28850期盐水量(升)(流量模式) 周清洗时间(分钟)米控制流程过滤器工位1:0Jo出水;主0再生(起始工位〉工迦:0l0出水;主曰泔洗工位3:0l曰出水;圭扌出水工龆:ˉ拚◇到Ⅱ再生:圭0山水工位5:△l臼油洗;圭曰出水工位6:0lo出水:主扌山水布水器进水电动阀出水单向阀 ∷0